1. 07-07-2004
    Views:
    115,468
+ Post New Thread
Page 1 of 52 1 2 3 11 51 ... LastLast
Threads 1 to 50 of 2552

Forum: AU Series Mechanical

AU/AU2/AU3 Falcon/Ute/Wagon/Fairlane/LTD

  1. Exclamation Sticky Thread Sticky: Read before posting a question!

    If you wish to post up a question in these mechanical discussion rooms, please do the following. 1) Do a search. There's thousands of threads so chances are that your question has already been answered. By doing a search, you'll get your answer straight away and it means that the forum isn't...

    Started by PaulST‎, 28-07-2011 12:12 AM
    • Replies: 0
    • Views: 12,610
    28-07-2011, 12:12 AM Go to last post
  2. Sticky Thread Sticky: Show us your Falcon/Fairlane.

    We encourage everyone to post up a few photos of your pride and joy. These rooms are primarily to discuss technical/mechanical issues so we ask that you post up photos in the Your Ride room.

    Started by PaulST‎, 26-12-2010 06:51 PM
    • Replies: 0
    • Views: 11,998
    26-12-2010, 06:51 PM Go to last post
    1. Removing Rear Extension Housing Ford AUII on BTR93LE Auto Trans

      Can anyone provide me with info as what needs to be done to remove rear extension housing on BTR93LE Auto transmission. I need to replace bush and seal due to leak. The Gregory's No 274 Falcon service repair manual does not explain enough. Any advice is welcome.

      Started by bondy99‎, Today 12:56 AM
      • Replies: 0
      • Views: 30
      Today, 12:56 AM Go to last post
    2. AUII VCT solenoid removal

      G'day all, I have a leaking solenoid at the VCT unit at the front, it is not leaking at the oil line at the banjo connection. Ellery's manual does not give much detail in removing the solenoid, has any member done this and able to advise? cheers Bill.

      Started by zbm‎, 23-01-2010 10:37 PM
      • Replies: 10
      • Views: 3,459
      12-08-2017, 04:01 PM Go to last post
    3. AU wagon GVM

      I am looking at towing a caravan and need to find the GVM for my 2002 au wagon to show the scalies if I am pulled up, but am having no luck. Does anyone know where I can get info on this please?

      Started by Fini‎, 23-07-2017 09:44 AM
      • Replies: 3
      • Views: 282
      03-08-2017, 08:58 AM Go to last post
    4. AU3 2002 power steering fluid - how to do full flush

      Hi all Have a 2002 Falcon AU3 sedan 4.0L 6 cyl LPG Noticed the power steering pump was making loud noise for first time - had a look and the pump had no oil in it. Noticed some power steer fluid on the top of the alternator Went and purchase some Penrite power steer fluid suitable for EF...

      Started by steve123‎, 26-07-2017 12:14 AM
      • Replies: 1
      • Views: 238
      26-07-2017, 09:29 PM Go to last post
    5. Anyone have a 99 AU 4.0 Used Exhaust/Tyres 4 Sale in Sydney?

      hey guys if anyone here has an exhaust for a 99 AU Ute 4.0 and lives close to Rydalmere....let me know also need some tyres it's about $200 or so for a new exhaust, and that's stock basic. and about another $230 for a set of Tyres.

      Started by JamieM‎, 25-07-2017 06:33 AM
      for sale, wanted
      • Replies: 0
      • Views: 163
      25-07-2017, 06:33 AM Go to last post
    6. Help Passing Blue Slip Advice Needed

      howdy my 99 AU ute has been out of rego for 12 months. it's only done 150k was talking to the guy I would get the blueslip done by and he was obsessively fanatical about having a car get a blue slip - should look 100% out of the factory. (or maybe he just didn't want to do it)

      Started by JamieM‎, 20-07-2017 11:42 AM
      au ute, blue slip
      • Replies: 1
      • Views: 201
      20-07-2017, 01:17 PM Go to last post
    7. coil pack

      AU series 2 , 6 cylinder is going through coil packs every few months. Any suggestions on what could be causing it and is there checks I could carry out . Much appreciated

      Started by poll‎, 14-07-2017 02:23 PM
      • Replies: 1
      • Views: 248
      16-07-2017, 06:16 PM Go to last post
    8. AU2 5 speed gearbox

      Hi Guys, I've got a Falcon AU2 XR8 ute with 5speed gearbox, had it for the past 4 years and now the gearbox has started to whine in 1st,2nd,3rd. I guess its bearings?? Its a Tremec T50D box so will any other model gearbox fit as a replacement?? Thanks

      Started by fonzeford‎, 12-06-2017 12:32 PM
      • Replies: 10
      • Views: 1,624
      11-07-2017, 09:52 PM Go to last post
    9. Trying to reprogram new remote for locks, demister not working

      Hi all Found plenty of info regarding reprogramming remotes but my demister isnt working. The vehicle is a series 3 AU station wagon. The cluster of 4 switches (demister, antennae, traction control and locks) are not working. Had an auto electrician look at it and he couldn't find any issues...

      Started by Fricken Chicken‎, 07-04-2017 10:44 AM
      • Replies: 5
      • Views: 2,217
      16-06-2017, 01:30 PM Go to last post
    10. AU II XR8 sedan

      I am giving my XR8 its 100,000km birthday! Yes, she has just done 100 thousand genuine kms. I have a pair of Rebel skirts & Rebel rear bar to put on her, but firstly I am getting them painted in my colour. Can anybody give me any tips or advice on fitting skirts & bars please?

      Started by xr8220‎, 15-05-2017 08:19 PM
      • Replies: 0
      • Views: 758
      15-05-2017, 08:19 PM Go to last post
    11. Talk to me about swapping 4.0L I6 unit for XR8 powerplant

      I have a 1999 AU Series 1 Fairmont in immaculate condition with the 4.0L I6 INTECH powerplant onboard (automatic box). I'm thinking of procuring a manual AU XR8 on the cheap and shifting the V8 unit / gearbox into the Fairmont. Anyone have any thoughts on this? is it a particularly difficult...

      Started by Tickford Prolific‎, 01-02-2016 12:16 AM
      • Replies: 5
      • Views: 2,515
      15-05-2017, 08:14 PM Go to last post
    12. White spark plug au111

      Hi. Series 111 AU HAD A CATASTROPHIC COIL PACK FAILURE. After fixing it, 500 km later ,the spark plug Colour is very WHITE on the tip. (lean burn maybe) If the steering pressure switch is plugged in to a new or old sensor, the engine stalls on take off. So it runs perfectly with this...

      Started by ang22221‎, 13-05-2017 04:10 PM
      • Replies: 1
      • Views: 335
      13-05-2017, 04:52 PM Go to last post
    13. Dual Fuel won't start or run on petrol (AU)

      Hi Guys, First post, did a quick search couldn't see anything. Have had a dual fuel fairmont wagon for about 4 months. Was advised to run about 10 litres of fuel every month. Worked fine the first 3 months. The last time I did it though I pretty much emptied the fuel tank. Now it won't start or...

      Started by jk5954‎, 12-08-2013 03:05 PM
      • Replies: 8
      • Views: 8,830
      08-05-2017, 09:12 AM Go to last post
    14. Ford AU won't idle on Gas when it reaches a certain temp

      Hello hopefully you guys can help, We've been having troubles with this for ages. We put a new/used engine with lower Km into my dads car which has a factory fitted Ford gas system... Everything has been fitted correctly and runs perfect on Petrol and appears to run perfect on Gas until the cars...

      Started by JSSoverseer‎, 14-01-2013 09:05 PM
      ford au, gas, idle, stall
      • Replies: 12
      • Views: 7,477
      10-04-2017, 09:31 PM Go to last post
    15. Auiii falcon lpg dangerous stalling problem whilst driving

      Re: 2002 Falcon Sedan AUIII 6CYL Auto LPG (dedicated LPG not dual fuel) Battling with the following problem since December 2016: The engine stalls whilst driving in these circumstances mainly > when going downhill at about 70 kph, touching the brakes to slow and shifting auto to third gear...

      Started by steve123‎, 05-04-2017 07:28 PM
      • Replies: 1
      • Views: 1,120
      05-04-2017, 08:26 PM Go to last post
    16. 2002 AU3 Falcon starter motors - which better

      Re: my 2002 AUIII Ford Falcon 6cyl 4.0 ltr (factory LPG) Sedan Need a new starter motor - its clunking and screeching...but still just kicking over There are two Bosch starter motors that would suit my above car: 1] A Bosch BXF456, ZPN-14234 which is 1.1 kw power and 2] the other a Bosch...

      Started by steve123‎, 26-08-2016 12:30 AM
      • Replies: 4
      • Views: 1,970
      05-04-2017, 06:41 PM Go to last post
    17. AU 1 alternator

      Does anyone know (from what I have been told) what the wiring modification is to allow a later model alternator (AU 2 - BA) to be fitted to an AU1 series Ford?

      Started by rfoden‎, 30-10-2007 06:34 PM
      • Replies: 4
      • Views: 4,431
      05-04-2017, 01:57 PM Go to last post
    18. Angry Au2 headlight switch replacement

      Hi my wifes au2 fairmont head light switch has fallen to bits ( front cover fell off and only circuit board left in dash ) she took it to the local mechanic becauce she could not turn headlights off. The mechanic said its a dash out job to replace it with a new $200 + switch . Got hold of a second...

      Started by Zana‎, 23-03-2017 09:24 PM
      • Replies: 3
      • Views: 513
      03-04-2017, 09:56 PM Go to last post
    19. AU 11 fluctuating power

      Yesterday my son drove my Fairmont to Adelaide. He said it drove fine on the trip down but started playing up with stalling at intersections, having no power to go up hills and generally surging when he accelerated. He took it to a mechanic who found a torch a different mechanic had left under the...

      Started by Pababear‎, 02-03-2017 11:25 AM
      • Replies: 0
      • Views: 938
      02-03-2017, 11:25 AM Go to last post
    20. HVAC Vacuum Hoses (AU3)

      Hi My Au falcon series 3 wont swap vents and i think its due to HVAC vacuum hoses Has anyone got a pic or diagram for the Vacuum hoses for Vent Switch I have the manual but it only seems to have series 1 and series 2 diagrams thanks

      Started by AuMum‎, 23-01-2017 06:49 PM
      au falcon, series 3, vacuum hoses
      • Replies: 3
      • Views: 1,251
      24-01-2017, 02:22 AM Go to last post
    21. Rear end rattle when driving

      Hi Guys, New guy here i think i have narrowed it down to shock absorbers, however when i jack under the chasis up the tyre wont get off the ground. I was checking for wheel bearing, but since the tyre would not lift i think its shocks. It is lowered not sure if sport lowered or super low, could...

      Started by Toby R‎, 19-01-2017 12:16 PM
      • Replies: 5
      • Views: 1,087
      20-01-2017, 07:37 PM Go to last post
    22. Engine swap

      Hi guys I was wondering if anyone could help me solve a problem. I have an au flat tray 6 cylinder. I have purchased a 260 boss from 05 ba xr8. I have most wiring except steering colon and ignition. I can get it to wind over but it won't open fuel pump and injectors. Does anyone have any idea?...

      Started by Scottmmm‎, 20-01-2017 11:02 AM
      • Replies: 0
      • Views: 606
      20-01-2017, 11:02 AM Go to last post
    23. ute overheating with ac on

      Hi guys, AU series 3 ute overheating when I run the air con. Turn the aircon off and the temp gauge drops back to normal even on a hot day. ...

      Started by poll‎, 08-01-2017 10:35 AM
      • Replies: 1
      • Views: 5,477
      08-01-2017, 01:05 PM Go to last post
    24. AU 11 Brake Problem

      while driving the other day I noticed that the brakes seemed to need more pedal effort to slow down. After some time I noticed the brake warning light come on so stopped the car and checked the master cylinder noticing that the fluid reservoir was close to empty. Drove carefully to a nearby auto...

      Started by Craber47‎, 04-01-2017 02:41 PM
      • Replies: 1
      • Views: 2,739
      04-01-2017, 09:58 PM Go to last post
    25. AU Falcon ute Power mirrors

      Hi all, Could someone point me in the direction of the location for the fuse for the power mirrors please? Cannot find it anywhere in the wiring diagrams( if it exist's at all). Thanks in advance.

      Started by Grungle‎, 03-11-2016 12:22 PM
      • Replies: 2
      • Views: 1,301
      04-11-2016, 01:44 PM Go to last post
    26. au falcon boot problem

      I have an au falcon and i have recently had trouble as the boot wont unlock with the keypad or the dash but i have used a light tester and it shows that the boot lock is getting power and i even tried my lock in a mates car and it worked fine. i know that the remote and dash button is not the...

      Started by Beno21‎, 14-10-2016 11:43 PM
      • Replies: 0
      • Views: 1,113
      14-10-2016, 11:43 PM Go to last post
    27. Flat spot when accelerating

      I purchased a 2002 AU Series III Forte wagon a few months ago. It drove really smoothly and was great to drive. A few weeks later it developed a bit of a flat spot (or miss) when accelerating from take off or low revs. I went to the mechanic who said to replace my plugs and leads which I then...

      Started by dannal‎, 17-11-2015 09:19 PM
      au flat spot accelerating
      • Replies: 21
      • Views: 5,278
      18-09-2016, 01:00 PM Go to last post
    28. Lack of power

      My 1998 Au blew the harmonic balancer and over heated, i replaced the balancer, but it will not move?

      Started by John Bot‎, 17-09-2016 10:26 PM
      • Replies: 1
      • Views: 1,149
      18-09-2016, 12:58 PM Go to last post
    29. Recharging totally dead battery

      Hey guys Had some personal problems recently and got in a bit of a bad way, and could not afford my car rego. I should have started my car once a week, but forgot and now the battery is so dead it won't jumpstart with the booster pack. about 8-10 weeks I think, am I still able to...

      Started by JamieM‎, 05-09-2016 09:25 AM
      car battery, charging
      • Replies: 4
      • Views: 2,672
      11-09-2016, 01:13 PM Go to last post
    30. Instrument cluster gremlins (AUIII)

      I have a 2002 AUIII Falcon SR. Low kms on the clock. It has developed issues with the cluster, sometimes DTE function goes to zero quickly then back up to 999 then freezes. Another time all the gauges froze on engine start up along with a low level high pitched alarm sounding in one long tone. This...

      Started by S1NUT‎, 09-09-2016 03:41 PM
      • Replies: 2
      • Views: 1,641
      10-09-2016, 07:50 AM Go to last post
    31. AU Falcon Fuel Pressure Regulator Replacement

      I thought it might be a good idea to show how I replaced my fuel pressure regulator (FPR) on my AUII Falcon Utility today for those who are thinking of doing it. It is quite an easy job so I took some photos too. So here goes: 1: In the engine bay near the battery, take the lid off the relay box...

      Started by Jim Tudge‎, 21-09-2013 07:55 PM
      • Replies: 15
      • Views: 15,831
      06-09-2016, 12:34 PM Go to last post
    32. Cleaning Headlights

      For anyone who isn't aware I just recently got a new AU Series 3 XR6, I got new headlamps and parker lights, I've installed them but with a slight issue or two that I think I'll need to fix. When changing my parker lights the globe on the passenger side was not only not working but was actually...

      Started by DK-Matty‎, 01-09-2016 12:27 AM
      • Replies: 4
      • Views: 1,833
      05-09-2016, 12:54 PM Go to last post
    33. AU fuel consumption

      Question have recently purchased 99 falcon forte and filled my tank to over 60 litres of fuel drove 409kms before gauge showing empty tank light and gauge completely in red, is this right? I was running air con for most of driving time as its summer in brisbane and 300kms was highway driving the...

      Started by lockdownpreston‎, 24-01-2009 04:44 PM
      2 Pages
      1 2
      • Replies: 25
      • Views: 12,844
      27-08-2016, 03:53 PM Go to last post
    34. Blue Bayonet parker light bulbs

      I brought and installed these: Problem is the parker ligh bulbs provided are not a match to my AU XR6, I need Bayonet bulbs. Im afraid that LED's might be too bright and illegal, so im thinking of buying these as the blue head lights do nothing unless you get on your knee's and look then...

      Started by DK-Matty‎, 23-08-2016 12:07 PM
      • Replies: 4
      • Views: 1,269
      24-08-2016, 09:54 AM Go to last post
    35. Question au power steering fluid

      guy at sprint has recommended the following as being recommended by ford,nulon 75w-85 smooth shift manual gear box&transaxle oil,does this sound right,would appreciate advice as i am about to replace power steering pressure switch for the fifth time in six years

      Started by supa‎, 27-04-2012 07:31 PM
      • Replies: 18
      • Views: 20,113
      22-08-2016, 12:54 AM Go to last post
    36. Cracked my new AUIII XR6 Bumper... Suggestions?

      I just got this beautiful blue 2002 Series III XR6 with a manual transmission only 9 days ago! Long story, please don't ask. I'm absolutely bleeding about this! I need a new left side skirt. Color: NR Blue Paint/Trim Code: NR/B2

      Started by DK-Matty‎, 02-08-2016 07:04 AM
      • Replies: 8
      • Views: 1,656
      20-08-2016, 02:58 AM Go to last post
    37. AU windscreen wiper failure

      Has anyone ever had this problem? Symptoms: After 2 hours of driving in rain, wipers "stopped." Slightly up from their bottom parked position at the bottom of the screen. Checked the wiper fuse - ok. Haynes book and www. do not indicate there is a windscreen wiper relay to check. THEN:

      Started by RRM‎, 03-08-2016 02:21 PM
      • Replies: 1
      • Views: 971
      03-08-2016, 04:26 PM Go to last post
    38. Question A.b.s, airbag, battery.

      Hey fellas I have a ( XR6 S3 VCT AU UTE ) and the on the way to work the Airbag,ABS,Battery lights come on and the car shut down wont start nothing like its frozen I disconnect the Battery for 20min or so and it starts again any ideas...?? Thanx in advance.. Btw..It has new Battery..2-months ago.

      Started by Yetiman‎, 30-06-2016 09:13 AM
      • Replies: 1
      • Views: 1,215
      01-07-2016, 03:25 PM Go to last post
    39. AU Efi specs

      I have a AU XR8 and have downloaded a workshop manual recently. It is good but I am searching for more info on efi sensor specs. I want to check and compare readings to specs to diagnose a problem I am having. Does anyone have a link or info on sensor specs (coolant, IAT, airflow meter, crank...

      Started by DJFalcon‎, 29-06-2016 07:20 PM
      • Replies: 0
      • Views: 1,361
      29-06-2016, 07:20 PM Go to last post
    40. FG brakes into AU1 S Falcon

      Hi there, My first post in this forum so here goes, I've just put FG XR6 calipers and discs into my AU1 S Falcon and am curious as to whether I should, or need to, also upgrade the master cylinder. Given the size difference of the brakes I am uncertain whether the master cylinder is up to the...

      Started by mackbock‎, 27-06-2016 07:08 PM
      brakes, master cylinder, upgrade
      • Replies: 3
      • Views: 1,546
      28-06-2016, 07:18 PM Go to last post
    41. Tyre shop wheel alignment results - AU1 S/W

      Bought 4 new shoes today for our 180,000km, 1999 Forte station wagon. The tyre shop put her on their wheel alignment machine and some of the "before" results caught my attention: 1. Left front camber 0deg 48' (Slightly above allowable range 0deg 15' to 0deg 45') and not adjustable. 2. ...

      Started by RRM‎, 14-06-2016 04:25 PM
      • Replies: 0
      • Views: 931
      14-06-2016, 04:25 PM Go to last post
    42. coolant

      red or green coolant for a 2002 au v8 ?

      Started by xb‎, 23-04-2016 11:47 PM
      • Replies: 1
      • Views: 1,193
      24-04-2016, 12:27 PM Go to last post
    43. au 2 fairlane ghia traction control and abs light.

      fairlane ghia traction control and abs lights comes on just after start to drive. Whats it mean and what's the fix. The guy said he washed the car underneath and it started just after. he said clean up the wheel sensors, but not sure.

      Started by powerblade‎, 17-01-2016 05:33 PM
      • Replies: 2
      • Views: 1,479
      22-04-2016, 07:35 PM Go to last post
    44. au 2 brakes

      just fitted new tora dimpled discs and bendex gct pads all round to a 5 ltr ute seams to be good so far

      Started by xb‎, 16-04-2016 03:25 PM
      • Replies: 2
      • Views: 1,603
      21-04-2016, 09:12 PM Go to last post
    45. Multiple oil leaks in AUIII

      I got a standard service on my AUIII at automasters today (I was gifted a VIP card and thought may as well use it) Got a list of things wrong with the poor old car.. I'm unsure if these leaks are bad enough to fix asap, fix later, or not fix at all due to the age, kms of the car. That being...

      Started by TeamSAXON‎, 15-04-2016 10:49 PM
      au falcon, auiii, falcon, forte
      • Replies: 1
      • Views: 1,619
      16-04-2016, 11:41 AM Go to last post
    46. Front Wheel Bearing Hubs

      I am about to replace the wheel bearings but have been told that they require tensioning, can anyone verify this please and advise what the tension is?:rolleyes:

      Started by colcas‎, 28-01-2014 11:57 AM
      • Replies: 6
      • Views: 8,571
      11-04-2016, 07:47 PM Go to last post
    47. Noisy rear wheels AUII

      I have loud squeaky noises coming from the rear of my falcon. The noise STOPS whenever I apply the breaks. I have read through the service and repair Manuel and still cannot tell what the issue is. The noise only started when I had my breaks replaced. The noise is getting worse as time goes on. Any...

      Started by Fordgeneration‎, 12-03-2016 09:26 PM
      • Replies: 2
      • Views: 1,594
      13-03-2016, 01:17 PM Go to last post
    48. Ford AU111

      Hi Everyone, I am searching for some globes for the AU111 with the woodgrain panel and digital aircon display. There are two globes for the display and 2 for the control buttons underneath. I cannot find replacement globes anywhere here in Perth. Any ideas would be appreciated cheers .

      Started by jumbocam‎, 24-02-2016 05:30 PM
      • Replies: 6
      • Views: 1,923
      24-02-2016, 10:21 PM Go to last post
    49. Would you jack up a solid-axle Falcon by a trolley jack under the diff? (AU)

      AU stationwagon, this is my first Falcon of any kind, hence a very beginner question... Are the rear axles of these cars strong enough, that you can jack the rear up in one go with a jack under the diff casing? Or does this run the risk of bending the axle? Or is it best to jack up one side...

      Started by RRM‎, 13-02-2016 11:19 AM
      • Replies: 3
      • Views: 1,981
      15-02-2016, 06:23 AM Go to last post
    50. AU II 4.0 falcon rough idle

      Hi, i have an AU II Falcon ute 4.0 which idles rough on gas and petrol. Sometimes when I shift from park to drive it stalls and other times its perfect. I have changed the leads and plugs but this has made no difference. The car accelerates without backfiring or spluttering however nearly stalls...

      Started by apisano01‎, 13-05-2009 08:44 PM
      • Replies: 3
      • Views: 5,706
      20-01-2016, 05:01 PM Go to last post

    + Post New Thread
    Page 1 of 52 1 2 3 11 51 ... LastLast

    Forum Information and Options

    Moderators of this Forum

    Thread Display Options

    Use this control to limit the display of threads to those newer than the specified time frame.

    Allows you to choose the data by which the thread list will be sorted.

    Order threads in...

    Note: when sorting by date, 'descending order' will show the newest results first.

    Icon Legend

    Contains unread posts
    Contains unread posts
    Contains no unread posts
    Contains no unread posts
    Closed Thread
    Thread is closed
    Thread Contains a Message Written By You
    You have posted in this thread

    Posting Permissions

    • You may not post new threads
    • You may not post replies
    • You may not post attachments
    • You may not edit your posts